Luftkappe Air Piston - Fox & RockShox Forks

Product Description

Make a good fork a great fork.

Introducing the Luftkappe air piston kit for:

  • Fox 34, 36 & 38
  • Rockshox Pike, Yari and Lyrik Solo Air forks
  • Rockshox Zeb / Domain

Taking everything we learned with the Corset air sleeves, the Luftkappe is a new air piston assembly that enlarges the negative air chamber to reduce the initial spring rate. This lets you run higher air pressure for more support in the middle and end of the stroke with improved sensitivity in the start of the stroke. User installable and simple to set up, the Luftkappe transforms a good fork into a great fork.

  • Coil-like feel without the harsh bottoming of a completely linear spring
  • Lower initial spring rate increasing sensitivity
  • Improved mid stroke support & control
  • Compatible with stock bottomless tokens
  • Superior bump compliance and traction
  • Reduced hand fatigue
  • Reduces required compression damping
  • Optional 10mm shaft clamps available for self-install

Installation Tools


Fox 34/ 38 NA2 Evol 2018+

Roll Pin Tool
Bullet Tool
Shaft Clamp


Fox 36 NA2 Evol 2018+

Roll Pin Tool


 


Fox 36 NA 2015-17

Shaft Clamps


 


RockShox LK-A1 & LK-A2

Shaft Clamps


RockShox Zeb / Domain

Shaft Clamps


RockShox Lyrik/ Pike 2023+

Shaft Clamps

20mm Hex Adaptor

Installation Guide & Manuals

WARNING: VORSPRUNG products should be installed and serviced by a trained bicycle service technician, in accordance with both VORSPRUNG and original manufacturers' specifications. If you have any doubt whether or not you can properly service your suspension product, or you have not performed this kind of work before, then please DO NOT attempt it. Improperly serviced products can fail, causing the rider to lose control resulting in SERIOUS INJURY OR DEATH. That's not a joke. Don't mess around with it if you don't know what you're doing, because the best case scenario is usually that you damage something in the process. Do not perform any kind of service on your suspension whilst drunk, high or stupid. We accept no responsibility nor liability for component damage or failure of any description in the case of self-installed units.

Luftkappe Air Piston - Fox 34EVOL (2018+)

Luftkappe Air Piston - Fox 36EVOL (2018+)

Luftkappe Air Piston - Fox 38 (2021+)

Luftkappe Air Piston - Fox 34NA2 (2016-2017)

Luftkappe Air Piston - Fox 36NA (2015-2017)

Luftkappe Air Piston - Rockshox Pike/Lyrik/Yari (2013-2022)

Luftkappe Air Piston - Rockshox Pike/Lyrik (2023+) 

Luftkappe Air Piston - Rockshox Zeb & Rockshox Domain

 

Delivery

For spare parts, if they are in stock we will send them out the same day if we receive the order before midday (except weekends). If we receive the order after midday, we will do our best to despatch them same day, but it may be the following working day. Orders placed after 3pm on Friday will be despatched on the following Monday. We normally send spare parts by Royal Mail post (see below or our 'Shipping' page for cost/delivery times).

Forks, shocks and large/heavy orders go by courier. UK deliveries are with DPD Local, for overseas customers it's DPD, FedEx or DHL.  In all cases these are fully tracked services and you'll need to sign for the delivery - please provide a suitable address with extra instructions if necessary.

Returns

You may return your order unused, within 14 days for a refund if you no longer require it, provided it is returned with its original undamaged packaging and is unused and unmarked. Please note, we do not refund postage unless items were supplied in error or are faulty.

Picking mistakes do sometime happen. If we supply the wrong part or there are parts missing from your order please let us know within 14 days of receipt so that we can correct the mistake. In the case of picking errors we will refund your postage costs on the returned item.

Faulty goods will be replaced with the same item or a suitable equivalent, as appropriate.

TF Tuned cannot be held responsible for the non-receipt of returned goods so please ensure you use a tracked and/or insured service as appropriate to the value of the goods you are returning.

Customer Reviews

said...
"The staff were very helpful and took their time to answer all questions I had, the delivery time was very quick, the bike now seems to ride higher in its travel, feels more pop in the fork not as soft in the mid travel, haven't tested fully but so far more than happy with my purchase, installation was easy following included instructions, thank you TFT."
Star Rating 5
STAFF REVIEW
said...
"I don’t bother to typically write a review, but the luft is an ace bit of kit. My 38’s are way more initially sensitive and plush. Also, shout out to Adam for his advice, total pro to deal with, and friendly to boot! Thanks TF. "
Star Rating 5
Staff response...
"Good to hear! Thanks for the review. Ruth @TFT"
said...
"I was really disappointed, when the Debonair Pike fork I ordered (from a different source) turned up with a Solo Air spring in it, but excited because I knew that that meant I could do a Luftkappe upgrade. I have previously had a Luftkappe, in a 2017, 650b, 130mm Pike, so I knew how good it would ride. I had been riding the Solo Air spring in my 2018, 29", 150mm Pike for a couple of months, and just about got it to where I was happy, but once I fitted the new Luftkappe my fork was transformed. It is now far plusher off the top, so I get much less of a buzz in my hands and wrists, but it also absorbs the big hits really well (with 3 tokens fitted). The fork is fitted to my daily driver, which rocks everything from 25 mile round trip commuting, to most of the DH trails at Gawton, and everything in between. With the Solo Air spring, I found that I was not getting such a good range of useable compression damping, as well as a much harsher ride on chattery trails, like we have on Dartmoor. The new Luftkappe just makes the fork feel so much closer to the 2019, 180mm Lyrik that I have on my big rig. There is a good amount of mid-range support, so you don't feel that you're diving into corners, or sinking on landings from drops and jumps, but at the same time it is really supple off the top of the stroke. I guess the bottom line is that the Luftkappe spring is on par with, or possibly slightly better than, the latest Debonair offerings from Rockshox. If you have an older fork, and want it to feel like a newer one, get a Luftkappe spring fitted."
Star Rating 5
said...
"Good product, fork is working much better.. "
Star Rating 4
said...
"Absolutely worth it. Not good with tech talk but damn my lyrik feels better now "
Star Rating 5
STAFF REVIEW
said...
"Does what it says. After being disappointed with many suspension modifications, I was cautious with my expectations regarding the Luftkappe. I was pleasantly surprised to find that the added midstroke support and small bump compliance were improved dramatically. I recommend this upgrade to everyone"
Star Rating 5
Staff response...
"Thanks for the feedback Pawel. Ruth @TFT"
STAFF REVIEW
said...
"Purchased the luftkappe fit my yari was easy to fit with clamps l do feel a difference when riding . I have no tokens fitted and slightly more air good product"
Star Rating 5
Staff response...
"Thanks for your review Alex - good to hear that it has made a difference! Ruth @TFT"
said...
"So much better small bumb compliance and overall function of the fork. "
Star Rating 5
STAFF REVIEW
said...
"My second Luftkappe upgrade and my mate got one for him also. This just work! Great service from Tftuned again. "
Star Rating 5
Staff response...
"Thanks Jukahia! Enjoy the ride. Ruth @TFT"
said...
"Great Products and super fast delivery"
Star Rating 5
said...
"Brilliant upgrade fitted in an hour with no previous experience,transformed my yari’s Small bump sensitivity is amazing the fork is just so much nicer to ride."
Star Rating 5
said...
"Probably one of the best and cheapest upgrades for your fork. It really transformed the way fork behaves. Great small bump sensitivity and mid-stroke support. Worth every penny "
Star Rating 5
said...
"I fitted this as I felt my pike forks lacked initial small bump sensitivity. However I fitted the luftkappe along with a new charger unit. What a difference. The fork now feels silky smooth."
Star Rating 5
said...
"Purchased my Luftkappe kit after much reading and have found it does what Vorsprung claims. Very pleased. Fitted it myself in about an hour."
Star Rating 5
said...
"Absolutely fantastic product! beautifully finished, easy to install and has transformed my forks. I now have superb small bump compliance, with fantastic mid stroke support and a nice end of stroke ramp up. All this without needing to run extra tokens etc. Which i always found improved mid and end of stroke support but at the sacrifice of sensitivity. Basically Rockshox have incorporated the Luftkappe into their new debonair 2018 forks (or looks it from where i sit) If you have a 2017 or earlier Pike this is the best upgrade £4£ you can make IMO"
Star Rating 5
said...
"Makes for a super plush fork. Fantastic upgrade "
Star Rating 5
said...
"Liked the first Luftkappe I bought so much I purchased a second to go in the fork of my other bike. Much improved mid range support. Highly recommended. "
Star Rating 5
said...
"Hi, must say this really is an improvement ! I have Yari -16 boost fork with 150mm and had issue it running too deep or hard. Now its firm, but really like the small pump sensitivity/ability take hits in Enduro races. Also now that I can adjust pressure way I like it & adjust tokens (only one now) way I like, fork has good mid stroke support & sensitivity. + I put low friction seals in at same, so these together made my fork feel like top line coil fork compared to old stock Yari. "
Star Rating 5
said...
"Great upgrade for my 29" RS Lyrik 160mm. Buy the 10mm clamp if you don't already own one. Beginning stroke got more plush even with 20psi more. "
Star Rating 5
said...
"Does exactly what it says on the tin, which is a rarity these days. Easy enough to fit, if you follow the instruction video on vorsprung website. Heat the shaft with a heat gun or something before attempting to remove the bolt, otherwise you will chew it up, and you need to reuse it."
Star Rating 5
said...
"Unfortunately I did a failure during installation and I lost ~10mm of stroke, :-( So I had to reinstall it again- but then it worked really good! So take care when you install it to save your time and enjoy your new fork :-)"
Star Rating 4
said...
"Luftkappe was relatively easy to install. More air was required (for me above the recommended extra 10%). The biggest plus for me is the fantastic mid stroke support. Prior to the instal, my Yari fork was great at the little bumps, high speed rock gardens, etc, and ramped up at the end of the stroke (with a couple tokens) to reduce bottoming out but it always lacked the support for boosting off jumps or landing after small drops etc. Great improvement, very pleased."
Star Rating 5
said...
"Superb upgrade for your Pike. "
Star Rating 5
said...
"It's alright, I thought I'd have notice more support, I may have to play more with setting ... Work in progess (let's say)"
Star Rating 4

Luftkappe Air Piston - Fox & RockShox Forks

in stock In stock

Choose option:
from £96.00 inc VAT

You may also need:
Luftkappe Installation Tools
Luftkappe Installation Tools
from £12.00 inc VAT

updown
Home Delivery

UK mainland delivery from £6.00